Power Steering Pump Failure? Questions - North American Motoring


Stock Problems/Issues Discussions related to warranty related issues and repairs, or other problems with the OEM parts and software for MINI Cooper (R50), Cabrio (R52), and Cooper S (R53) MINIs.
Sponsored by:
Sponsored by:

Power Steering Pump Failure? Questions

Reply
 
 
 
Thread Tools Search this Thread
  #1  
Old 04-16-2018, 07:49 AM
SooperCoopers SooperCoopers is offline
1st Gear
Thread Starter
 
Join Date: Feb 2013
Posts: 45
Thanked 0 Times in 0 Posts
Power Steering Pump Failure? Questions

Hey everyone,

I have a 2003 R53 with just over 150k miles on it.


Lately, I have noticed a constant whining noise while driving the car. I assumed this to be a dying power steering pump, but I hadn't experienced any power steering losses so I disregarded it for a week or so..

Well, just this morning I tried to start the car up after it had been sitting overnight. The car started up very rough, lights were flickering in the cluster, there was also a beeping noise, my headlights were flashing as if they were not getting enough power to stay on...Also, as soon as I go to turn the wheel, the car stalls.

Could a bad power steering pump be sucking the power from the battery and be causing these issues? Also, given my mileage, I am assuming im not covered under any warranty or recall am I?

Thank you!
Reply With Quote
  #2  
Old 04-16-2018, 07:59 AM
MINIAC MINIAC is offline
6th Gear
 
Join Date: Jan 2003
Location: Tsunami Zone
Posts: 2,141
Thanked 18 Times in 17 Posts
There is a recall ...

https://www.northamericanmotoring.co...ng-recall.html

If any of the power steering hoses are leaking they will make you pay for their replacement.
Reply With Quote
  #3  
Old 04-16-2018, 08:09 AM
SooperCoopers SooperCoopers is offline
1st Gear
Thread Starter
 
Join Date: Feb 2013
Posts: 45
Thanked 0 Times in 0 Posts
Thanks, I just entered my VIN on MINI's website and apparently this recall doesn't show up for mine.....dang.
Reply With Quote
  #4  
Old 04-16-2018, 08:29 AM
ECSTuning's Avatar
ECSTuning ECSTuning is online now
Platinum Sponsor
 
Join Date: Jan 2013
Location: Wadsworth,OH
Posts: 24,857
Thanked 232 Times in 227 Posts
Might be past the time frame I have mine checked out right when the letter went out. I would call your local dealer and have them check out for you.
Reply With Quote
  #5  
Old 04-16-2018, 11:34 AM
Whine not Walnuts's Avatar
Whine not Walnuts Whine not Walnuts is offline
Administrator
 
Join Date: Mar 2013
Location: Fuquay Varina, NC
Posts: 4,192
Thanked 402 Times in 372 Posts
Going to move you to the Stock Problems/Issues area.

There is a 100 amp fuse for the PS pump (on bottom of engine fuse box and you have to turn the fuse box over in order to see) and would think if you the pump was sucking so much voltage the car would stall that the fuse would pop first. You have verified that the belt system/pulleys are all functioning correctly?
Reply With Quote
  #6  
Old 04-16-2018, 01:35 PM
gumbedamit gumbedamit is offline
4th Gear
 
Join Date: Oct 2016
Location: Atlanta Georgia
Posts: 577
Thanked 31 Times in 31 Posts
Seems more like an electrical problem, check you battery and alternator. Make sure you have proper voltage. As, WnW stated, if the pump was drawing to much juice, fuse would blow. Did you check the fluid level, could be the source of your whine.
Reply With Quote
  #7  
Old 04-16-2018, 06:25 PM
SooperCoopers SooperCoopers is offline
1st Gear
Thread Starter
 
Join Date: Feb 2013
Posts: 45
Thanked 0 Times in 0 Posts
Thanks for the replies everyone! I will check the fuse along with the pulley side of the car tomorrow. Ill also check voltages and report back...I did look at the PS fluid level and it was right where it should be.
Reply With Quote
  #8  
Old 04-17-2018, 03:58 PM
SooperCoopers SooperCoopers is offline
1st Gear
Thread Starter
 
Join Date: Feb 2013
Posts: 45
Thanked 0 Times in 0 Posts
might have found my issue. thanks folks!
Reply With Quote
  #9  
Old 04-17-2018, 03:58 PM
SooperCoopers SooperCoopers is offline
1st Gear
Thread Starter
 
Join Date: Feb 2013
Posts: 45
Thanked 0 Times in 0 Posts
think my car is weather tight?
Reply With Quote
  #10  
Old 04-17-2018, 04:40 PM
SooperCoopers SooperCoopers is offline
1st Gear
Thread Starter
 
Join Date: Feb 2013
Posts: 45
Thanked 0 Times in 0 Posts
one of the bolts is deee-stroyed...Can I buy this whole yellow assembly somewhere? I think the threaded bolts are all part of this one piece?
Reply With Quote
  #11  
Old 04-18-2018, 05:05 AM
ECSTuning's Avatar
ECSTuning ECSTuning is online now
Platinum Sponsor
 
Join Date: Jan 2013
Location: Wadsworth,OH
Posts: 24,857
Thanked 232 Times in 227 Posts
Yikes, yep water in there.

Check the drain tubes.

https://www.northamericanmotoring.co...-of-leaks.html

https://www.northamericanmotoring.co...mpartment.html





Thats really far gone and the fuse looks shot. Most people fix the leak, clean it up and replace it. 61126942507

https://www.northamericanmotoring.co...btty-cmpt.html




You might be able to save the cable with the end on it by getting a new eyelet and cleaning the old cable and clamping/ crimping it on. Then shrink wrap the end.
Reply With Quote
  #12  
Old 04-18-2018, 05:26 AM
MiniTigger's Avatar
MiniTigger MiniTigger is offline
5th Gear
 
Join Date: Jun 2015
Posts: 969
Thanked 25 Times in 21 Posts
Dang.
Reply With Quote
  #13  
Old 04-18-2018, 04:38 PM
SooperCoopers SooperCoopers is offline
1st Gear
Thread Starter
 
Join Date: Feb 2013
Posts: 45
Thanked 0 Times in 0 Posts
dang is right...i ordered the new module, should be here in 2 days..for the time being I did this quick fix, bypassing the
fuse.
Reply With Quote
 
 
Reply

Related Topics
Thread Thread Starter Forum Replies Last Post
Must Read About time Power steering pump failure !!! u68423 Stock Problems/Issues 575 01-29-2018 01:12 PM
Steering knuckle wear due to power steering pump failure lovely Stock Problems/Issues 1 08-20-2014 04:12 PM
The Great Power Steering Pump Failure/Problems Thread orvillespooner Stock Problems/Issues 734 03-13-2014 09:02 AM
Power Steering Got You Down? It May Be Your Power Steering Pump – By Pelican Parts PelicanParts.com Vendor Announcements 0 08-19-2013 11:06 AM
Power Steering Pump Failure- 2003 S LakeHelen Stock Problems/Issues 1 12-09-2005 05:49 AM


Thread Tools Search this Thread
Search this Thread:

Advanced Search

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off
Trackbacks are Off
Pingbacks are Off
Refbacks are Off

Forum Jump


All times are GMT -7. The time now is 10:05 PM.


North American Motoring is an independently operated web site supporting MINI owners and enthusiastsworldwide. As such it has no official relationship with MINI USA, BMW AG, or BMW of North America.All original artwork and design is Copyright © 2002-2004 North American Motoring.
We are a participant in the Amazon Services LLC Associates Program, an affiliate advertising program designed to provide a means for us to earn fees by linking to Amazon.com and affiliated sites.